Yearly Archives: 2019

Nissan Qashqai air conditioning not working.

The owner of this vehicle had taken his car to another garage for a air conditioning service but they could not complete the work as there machine had detected a leak but they didn’t have leak detection tool.

At Aarons Autos we have a nitrogen gas leak test kit that fills the system with nitrogen which is not harmful to the environment when released into the air.

Front end stripped down to find leak and then removal of the air conditioning condenser.

We used the air conditioning leak detection kit and with the gas escaping we pinpointed the leak to the air conditioning condenser behind the intercooler. We informed the customer of the air conditioning leak test result and after a estimated repair cost they gave us the go ahead to replace the air conditioning condenser.

Damaged air conditioning condenser.

New air conditioning condenser fitted.

After replacing the air conditioning condenser we performed another leak test and the system held gas as it should with no leaks detected.

We do air conditioning servicing, leak tests and repairs.

Aarons Autos is the best car servicing garage in the world

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info

Toggle panel: Platinum SEO Pack
Code editor selected

Vauxhall Corsa oil in coolant and timing chain noisy.

This Vauxhall Corsa came into the garage after the owner had notice that the coolant was being contaminated with oil. Whilst we were looking into the problem we also noticed the timing chain was very noisy and with no visible problems we informed the customer that we would need to strip the timing side of the engine to investigate the problem.

Vauxhall Corsa timing chain gasket failure.

On stripping the timing chain side of the engine both problems were quickly diagnosed. We found that the gasket separating the oil from the coolant behind the timing chain cover had failed letting the two mix together, also when the timing tools were inserted the timing chain was found to be stretched which was causing the rattling noise.

Vauxhall Corsa timing chain gasket (in black) failed.

Vauxhall Corsa timing chain gasket failure close up.

We replaced the timing chain, guides, sprockets and gasket then flushed the cooling system to remove any remaining oil from the system. After performing a intrim service and a full anti freeze change the Vauxhall Corsa engine was nice and quite and the oil was no longer mixing with the coolant.

Aarons Autos is the best car servicing garage in the world

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info

Fiat Ducato camper van radiator repair.

This Fiat Ducato camper van came into us after the customer complained that they had noticed a pink fluid leaking from around the front of the vehicle.

Fiat Ducato Camper van

We checked around the engine bay of the camper van and could see pink staining around the radiator indicating that there may be a leak. We used our coolant pressure tester and entered pressure into the cooling system and the leak from the radiator became apparent.

Fiat Ducato camper van radiator leaking

On removal of the radiator you could see where the radiator had failed and the coolant was leaking from.

Fiat Ducato camper van radiator damage

We replaced the radiator and filled with new anti freeze, the camper van was ready once again for many camping holidays.

Camper van, large van, small van service and repairs.

Aarons Autos is the best car servicing garage in the world

Your friendly car garage in Derby

Give us a call at Arrons Autos for more info

Toggle panel: Platinum SEO Pack
Code editor selected

Transit Van cross member on back order!

What do you do when a van that has failed an MOT on a rear cross member being excessively corroded (not much left at all) and requires a new one only to find the Dealers are on inevitable back order and non of the motor factors list the part?

Well, in our case we make one.

Transit van repairs at Aarons Autos — Old v New.

A sheet of steel and a bit of patience and ‘voila’ a new cross member for the van.

WELDING AT AARONS AUTOS DERBY — New beam in place.

Once welded in place its just a matter of sealing and painting the new cross member and its a job well done.

If your car or van fails an MOT on welding don’t hesitate to give us a call for a quote.

Aarons Autos for all your car or van requirements.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.

Vauxhall Meriva rotten subframe found on service.

This 2008 low mileage Vauxhall Meriva came into us for servicing and as we checked the vehicle over we noticed some surface rust on the subframe. Rust is never a good thing so to make sure the subframe still had its integrity that it needs we tapped the rust and we was shocked at what happened.

Not only did a massive chunk of rust/subframe fall off but we found the structural integrity of the steering rack mounting was found to be seriously rotten and in need of immediate action.

Vauxhall Meriva surface rust turned out to be large hole

Vauxhall Meriva subframe steering rack mount rotten

MOT Failure!

We contacted the customer and they popped down so we could show them how serious the fault was and agree on a action plan to solve the issue. We always assess expensive repairs on older cars to make sure that it is financially viable to repair the car and in this case due to the overall good condition of the car and the low mileage it was agreed to replaced the subframe.

We sourced a new subframe from the local main dealer and replaced it, after finishing the service the customer was happy to get his car back all repaired and ready for many more years on the road.

Are Ebay car parts worth the risk?

As a rule car parts are becoming more and more expensive and we sometimes recommend either we or the customer tries and find alternatives on the internet, but after our recent issues we will only be recommending OE parts from our suppliers from now on.

The first instance was a ignition barrel on a 2012 Citroen Relay that had failed. Calling the main dealer for a replacement barrel you had to buy a complete lock kit and it was over 700 pounds. Trying to look after our customer we found one on Ebay and purchased it on there behalf at a very low price. 2 days after fitting the new ignition barrel it failed making us look bad and causing the customer issues.

We managed to find an alternative replacement via Fiat main dealer and the vehicle has been fine since.

”Buy cheap, buy twice”

The second instance was a Vauxhall Meriva subframe that had rotten through, We spoke to the main dealer and the part was over 500 pounds, So again trying to look after our customer we managed to source one from Ebay at half the price.

The new subframe arrived and at a glance looked all good but as we started to fit the lower wishbones we found the o/s/f wishbone was fouling with the subframe. After taking many measurements we found that the front wishbone mounting bracket had been incorrectly welded in the wrong place by 1 cm. After talking to the unhelpful seller the part was returned and a main dealer one purchased and fitted with no problems.

Incorrectly welded wishbone mounting on a Vauxhall Meriva subframe purchased from Ebay

Over the years personally we have purchased parts from the internet with no problems but we thought we would give you a insight to when things don’t go to plan and why we will not be buying cheap parts from the internet in the future.

As the old saying goes ‘Buy cheap buy twice’.

Vauxhall Corsa non start – fixed

This Vauxhall Corsa came into us with a report from a breakdown company that the catalytic converter had collapsed blocking the exhaust making it a non start. We quickly determined that the Cat was infact fine and not the cause. On trying to start the car it would run but backfire and would not rev correctly.

Next we removed the inlet manifold and on removal we found that the lower part had infact blow off. On speaking to the customer they reported that the car did make a loud bang before it would not start again.

Manifold split in half!

Damaged Vauxhall Corsa inlet manifold after blowing apart

Vauxhall Corsa inlet manifold blown apart

After sourcing a new inlet manifold we fitted it and cleared all the ecu codes and the car ran as it should leaving a happy customer.

Dual Mass Flywheel Failure!!

Do you know if your car has a Dual Mass Flywheel? Do you know what a Dual Mass Flywheel is? Here’s the basics.

A Dual Mass Flywheel is basically what it says, it’s a Flywheel in two parts (Dual). The two separate parts are allowed to rotate slightly to create dampening when you release the clutch and to reduce engine vibrations being passed through to the gearbox.

This is done by heavy duty springs in between the the two separate parts of the Flywheel which allow the slight movement.

However, with all moving parts, especially ones under stress they wear causing noises, vibrations and lastly drive line failure!

Vibrations or Rattling?

This was a Dual Mass Flywheel we replaced recently on a Citroen C5, as you can see from the pictures when the old Flywheel had failed it was allowing the clutch to sit off centre causing vibrations. Once the new Flywheel and Clutch Kit were fitted it sat central again.

Once replaced the car was road tested and all vibrations and noises had disappeared.

If you have any concerns about vibrations or noises feel free to give us a call on 01332 205070 and we would be happy to help.

Rapid Supercharged Mini & Stunning Triumph GT6.

The Aarons Autos family has a large width of knowledge ranging across many different makes and models of vehicles with all of us working in different areas of the motor trade through our careers, from dealerships to specialists, Master tech’s and even engineering.

This Width of knowledge helps us when we have to work on older vehicles as this was where we first fell in love with the motor trade. We cut our teeth rebuilding carburettors, replacing points and condensers and grew up with king pins and grease nipples.

With this in mind when customers ask if we can work on their pride and joy classic cars we can be confident in our abilities.

The owner of this Supercharged Mini rang us after purchasing the car for some road rally events and some hill climb events to see if we could check over the geometry and make a few adjustments. We made a few small adjustments and got the customer on his way.

The owner of this beautifully restored Triumph GT6 Mk3 contacted us to ask if we could set up the camber and toe of his triumph after its complete restoration. Carrying out the camber adjustment on the front of the Triumph is done by either adding or removing shims on the lower wishbones and rechecking until the desired camber is obtained, the toe adjustment is carried out the same as modern vehicles. The rear camber is not adjustable but the toe is, the toe is adjusted by using shims again to lengthen/shorten the trailing arm.

If you have a classic car or even a modern classic and have any problems give us a call to see if we can help you on 01332 205070

Air Conditioning service and repair.

We may not have Air Conditioning in the garage but we do try and make it more comfortable for our mechanics Adam and Sean on hot days like today. Remember we service and repair vehicle Air Conditioning. Our Air Conditioning service is £84.00 inc vat and includes gas up to a extra 500 grams top up, give us a call today on 01332 205070.